What does the leak detection pump do?

Posted by

The leak detection pump is the component that often triggers those “Check Engine” lights when it detects small leaks that would be difficult to see. It is required by federal law because it ensures that your Evaporative Emission (EVAP) system is functioning correctly.


Your car may still be covered by the five-year/50,000-mile emissions warranty. If that is the case, you should not have paid a dime for this repair, as the Leak Detection Pump (LDP) is an emissions control device, just like the charcoal canister (also called vapor canister). If they are faulty, there should be no charge for repair or replacement. Challenge them with your receipts for a refund and additional repair of the canister. If they give you an argument about it, call Chrysler, and they will handle it.
 

Now, are you ready to learn more about the leak detection pump, so you will need to know?

Leak Detection Pump (LDP) Operation and Diagnosis

The Evaporative Emission system is designed to prevent fuel vapors from leaking from the fuel system. Leaks in the system, even small ones, can allow fuel vapors to escape into the atmosphere. Government regulations require on-board tests to ensure the Evaporative (EVAP) system is working properly. The leak detection system tests for leaks and blockage of the EVAP system. It also performs self-diagnostics.

During self-diagnosis, the Powertrain Control Module (PCM) first checks the Leak Detection Pump (LDP) for electrical and mechanical faults. If the initial checks pass, the PCM then uses the LDP to seal the purge valve and pump air into the system to pressurize it.

If there is a leak, the PCM will continue to pump the LDP to replace the air that is escaping. The PCM determines the size of the leak based on the speed/duration it must pump the LDP while trying to maintain pressure in the system.

EVAP Leak Detection System Components

    Service Port: used with special tools such as the Miller Evaporative Emission Leak Detector (EELD) to test for leaks in the system.
    EVAP Purge Solenoid: The PCM uses the EVAP purge solenoid to control the purging of excess fuel vapors stored in the EVAP canister. It remains closed during leak tests to prevent pressure loss.
    EVAP Canister: The EVAP canister stores fuel vapors from the fuel tank for purging. EVAP Purge Orifice: limits the purge volume.
    EVAP System Air Filter: supplies air to the LDP to pressurize the system. It filters out dirt while providing a vent to the atmosphere for the EVAP system.

Leak Detection Pump (LDP) Components

The main purpose of the LDP is to pressurize the fuel system for leak checking. It seals the EVAP system vent to atmospheric pressure so the system can be pressurized for leak tests. The diaphragm is powered by engine vacuum. It pumps air into the EVAP system to develop a pressure of approximately 7.5 ‘H20 (1/4) psi. A reed switch in the LDP allows the PCM to monitor the position of the LDP diaphragm. The PCM uses the reed switch input to monitor the rate at which the LDP pumps air into the EVAP system. This allows for the detection of leaks and blockages.

The LDP assembly consists of several parts. The solenoid is controlled by the PCM and connects the upper pump cavity to engine vacuum or atmospheric pressure. A purge valve closes the EVAP system to the atmosphere, sealing the system during leak tests. The pump section of the LDP consists of a diaphragm that moves up and down to draw air through the air filter and inlet check valve and pump it through an outlet check valve into the EVAP system.

  The diaphragm is pulled upward by engine vacuum and pushed downward by spring pressure, when the LDP solenoid is turned on and off. The LDP also has a magnetic reed switch to signal the diaphragm position to the PCM. When the diaphragm is down, the switch is closed, sending a 12 V (system voltage) signal to the PCM. When the diaphragm is up, the switch is open and no voltage is sent to the PCM. This allows the PCM to monitor the LDP pumping action as it turns the LDP solenoid on and off.

LDP at Rest (Unpowered)

When the LDP is at rest (no power/vacuum), the diaphragm may lower if the internal pressure (EVAP system) is not greater than the return spring. The LDP solenoid blocks the engine vacuum port and opens the atmospheric pressure port connected via the EVAP system air filter. The purge valve is held open by the diaphragm. This allows the canister to see atmospheric pressure.
Diaphragm Upward Movement

When the PCM energizes the LDP solenoid, the solenoid blocks the atmospheric port leading through the EVAP air filter and simultaneously opens the engine vacuum port to the pump cavity above the diaphragm. The diaphragm moves upward when the vacuum above the diaphragm exceeds the spring force. This upward movement closes the purge valve. It also causes a low pressure below the diaphragm, unseating the inlet check valve and allowing air to enter through the EVAP air filter. When the diaphragm completes its upward movement, the LDP reed switch changes from closed to open.

Diaphragm Downward Movement

Based on the reed switch input, the PCM de-energizes the LDP solenoid, causing it to block the vacuum port and open the atmospheric port. This connects the upper pump cavity to the atmosphere through the EVAP air filter. The spring is now able to push the diaphragm downward. The downward movement of the diaphragm closes the inlet check valve and opens the outlet check valve, pumping air into the evaporative system. The LDP reed switch changes from open to closed, allowing the PCM to monitor the LDP pumping activity (diaphragm up/down). During the pumping mode, the diaphragm will not drop far enough to open the purge valve.

The pumping cycle is repeated as the solenoid is turned on and off. As the evaporative system begins to pressurize, the pressure at the bottom of the diaphragm will begin to oppose the spring pressure, slowing the pumping action. The PCM observes the time from when the solenoid is turned off until the diaphragm falls far enough for the reed switch to change from open to closed. If the reed switch changes too quickly, a leak may be indicated. The longer it takes for the reed switch to change state, the tighter the evaporative system is. If the system pressurizes too quickly, a restriction somewhere in the EVAP system may be indicated.

Pumping Action

During certain parts of this test, the PCM uses the reed switch to monitor diaphragm movement. The solenoid is only energized by the PCM after the reed switch changes from open to closed, indicating the diaphragm has moved down. At other times during the test, the PCM will turn the LDP solenoid on and off rapidly to quickly pressurize the system. During a fast cycle, the diaphragm will not move enough to change the reed switch state. In the fast cycle state, the PCM will use a fixed time interval to cycle the solenoid.

EVAP/Purge Solenoid

The Duty Cycle EVAP Purge Solenoid (DCP) regulates the flow of vapor from the EVAP canister to the intake manifold. The Powertrain Control Module (PCM) operates the solenoid.

During the cold start warm-up period and hot start time delay, the PCM does not energize the solenoid. When de-energized, no vapor is purged. The PCM de-energizes the solenoid during open loop operation.

The engine enters closed loop operation after reaching a specified temperature and the time delay ends. During closed loop operation, the PCM cycles (energizes and de-energizes) the solenoid 5 or 10 times per second, depending on operating conditions. The PCM varies the vapor flow rate by changing the solenoid pulse width. Pulse width is the length of time the solenoid is activated. The PCM adjusts the solenoid pulse width based on engine operating conditions.

The Charcoal Canister or Vapor Canister

A maintenance-free EVAP canister is used on all vehicles. The EVAP canister is filled with granules of an activated carbon mixture. Fuel vapors entering the EVAP canister are absorbed by the charcoal granules.

Fuel tank pressure vents into the EVAP canister. Fuel vapors are temporarily held in the canister until they can be drawn into the intake manifold. The Duty Cycle EVAP Purge Solenoid is used to purge the EVAP canister at predetermined times and under certain engine operating conditions.
Diagnostic Trouble Codes (DTCs)

  •     P0442-Evap Leak Monitor 0.040″ leak detected
  •     P0455-Evap Leak Monitor Large leak detected
  •     P0456-Evap Leak Monitor 0.020″ leak detected
  •     P1486-Evap Leak Monitor Pinched hose found
  •     P1494-Leak Detection Pump SW or mechanical fault
  •     P1495-Leak Detection Pump Solenoid Circuit

Additional information provided courtesy of AllDATA

 
 
 

Leave a Reply

Your email address will not be published. Required fields are marked *